Advanced nitrogen removal using pilot-scale SBR with intelligent control system built on three layer network

Since eutrophication has become increasingly severe in China, nitrogen and phosphorous have been the concern of wastewater treatment, especially nitrogen removal. The stabilization of the intelligent control system and nitrogen removal efficiency were investigated in a pilot-scale aerobic-anoxic sequencing batch reactor (SBR) with a treatment capacity of 60 m³/d. Characteristic points on the profiles of dissolved oxygen (DO), pH, and oxidation reduction potential (ORP) could exactly reflect the process of nitrification and denitrification. Using the intelligent control system not only could save energy, but also could achieve advanced nitrogen removal. Applying the control strategy water quality of the effluent could stably meet the national first discharge standard during experiment of 10 months. Even at low temperature (t = 13°C), chemical oxygen demand (COD) and total nitrogen (TN) in the effluent were under 50 and 5 mg/L, respectively.     

厌氧／缺氧SBR反硝化除磷效能的研究

采用厌氧 缺氧SBR反应器对以硝酸盐作为电子受体的反硝化除磷过程进行了研究。结果表明 ,反硝化聚磷菌完全可以在厌氧 缺氧交替运行条件下得到富集。稳定运行的厌氧 缺氧SBR反应器的反硝化除磷效率 >90 % ,出水磷浓度 <1mg L。进水COD浓度对反硝化除磷的效率影响很大 ,在COD浓度 <180mg L时 ,进水COD浓度越高 ,除磷效率也就越高。较高浓度的进水COD浓度将导致有剩余的COD进入缺氧段 ,对反硝化吸磷构成不利影响。污泥龄为 16d时 ,厌氧 缺氧SBR反应器取得稳定和理想的反硝化除磷效果。污泥龄减少到 8d ,由于反硝化聚磷菌的流失导致反硝化除磷效率的下降。当污泥龄恢复到 16d时 ,经过一段时间的运行 ,反硝化聚磷菌重新得到富集 ,除磷效率恢复到 90 %以上。     

连续流分段进水生物脱氮工艺控制要点及优化

主要介绍了分段进水生物脱氮工艺的系统工作原理及工艺特性,并探讨了该工艺运行操作和设计的几个重要影响因素,如进水流量分配比、溶解氧、污泥回流比、C/N比等,并在此基础上讨论了分段进水生物脱氮工艺的优化控制对策.     

以pH和ORP作为脉冲SBR工艺的实时控制参数

为了实现脉冲SBR深度脱氮的实时控制，以某污水处理厂市政污水为处理对象，考察了脉冲SBR在深度脱氮过程中pH及ORP的变化规律。试验结果表明，pH及ORP的变化规律与脉冲SBR有机物去除、硝化与反硝化过程存在较好的相关关系。可以根据pH和ORP变化曲线上的特征点对脉冲SBR进行实时控制。并考察了污水C／N（COD／NH4^＋-N）对pH及ORP的变化规律的影响。在硝化过程中，C／N对pH及ORP曲线变化点的出现没有影响；在反硝化过程中，应结合pH值“硝酸盐峰”和ORP“硝酸盐膝”来判断低C／N污水反硝化的终点。在该试验中，出水TN低于2mg／L，TN去除率可达到96％以上。     

变频控制DO下SBR硝化反应控制参数及节能的中试研究

根据微生物好氧反应的需氧量调节曝气量在当今能源紧缺的形势下具有十分重要的意义.为了研究曝气量大小对SBR实时控制参数pH、DO的影响,采用变频器调节曝气量以控制系统不同的DO浓度,以60 m3中试SBR反应器处理北京市北小河污水处理厂城市污水,考察了硝化过程中pH值、DO与有机物去除及硝化过程的相关性,并引入了新的控制参数--变频频率f.试验结果表明,控制溶解氧浓度较低时,pH值不能作为硝化结束的控制参数,但可根据变频频率f的特征点判断硝化反应的结束;控制溶解氧为3.0 mg/L和4.0 mg/L时,DO、pH值、变频频率f都可作为硝化结束的控制参数,同时,变频控制可有效降低单位时间内风机的能耗.     

SBR法降解有机物规律的研究

本研究是以处理啤酒废水的试验为基础展开的。试验结果进一步验证了SBR法具有简易,快速、低耗等优点。除此之外,还得出以下结论:增加间歇反应时起始污泥浓度可以提高处理效率或减少反应时间;非限制曝气方式耐冲击负荷,需氧均匀,能缩短反应周期;间歇反应中微生物细胞的合成代谢占主导地位,对氮与磷的需要量大于传统的理论值。本文还指出SBR法是很适合我国国情的一种废水处理工艺,应当加强对它的研究和推广应用。     

A/O脱氮工艺的控制策略和应用性研究

根据A/O脱氮工艺的运行状况和影响因素 ,提出了应用在线传感器连续测定曝气池中DO浓度、氨氮浓度和硝酸氮浓度 ,并据此调节供氧强度、内循环回流量、有机碳源的投加以及硝化区和反硝化区的大小 ,这是保证A/O脱氮工艺良好处理效果的重要控制策略和思想。同时对近年来国外A/O脱氮工艺自动控制的应用及研究进行了简单的回顾。     

Genotoxicity of two novel pesticides for the earthworm, Eisenia fetida

In this paper, several studies were conducted to evaluate the genotoxicity of two pesticides, Imidacloprid and RH-5849, for earthworm (Eisenia fetida). Earthworms were exposed in different exposure systems to evaluate their acute toxicity and the genotoxicity of the two pesticides was evaluated by using the method of sperm deformity assessment, micronucleus test of root tip cells in Vicia faba, a mouse bone-marrow micronucleus test, and comet assay. LC(50) (interpolated concentration at which 50% mortality of test population occurs) for earthworms varied in different exposure systems. The results indicated that Imidacloprid was consistently more toxic than RH-5849 in all exposure systems. In this study, sperm deformity test was used to detect the potential adverse influences of pesticides on the reproduction of earthworms. The results demonstrated that significant induction of sperm deformity (p<0.01) and a dose-effect relationship displayed at Imidacloprid concentrations higher than 0.5 mg/kg dry soil. However, the sperm deformity frequency of groups exposed to RH-5849 did not show significant difference (p>0.05) from the control until the dose reached 100 mg/kg dry soil. The results of the V. faba micronucleus tests showed that micronuclei frequency of the exposed group did not show significant difference (p>0.05) from the control until the concentration of Imidacloprid and RH-5849 reached 100 mg/ml. The results of the mouse bone-marrow micronuclei test also indicate that two pesticides did not show significant effects (p>0.05) on the micronuclei frequency in mice bone-marrow cells until the dose reached 100 mg/kg for Imidacloprid and 300 mg/kg for RH-5849 (2/3 LD(50)). Although no genotoxicity was detected by using the micronucleus tests, the results of the comet assay showed that the two pesticides induce significant DNA damage (p<0.01) in earthworms and dose-effect relationships were displayed. The 'earthworm comet assay' is a rapid and sensitive way to screen chemicals or terrestrial environments for their DNA-damaging properties.     

DO对高氨氮渗滤液短程生物脱氮反硝化过程动力学的影响

为考察实际高氨氮垃圾渗滤液短程生物脱氮过程DO对以NO2--N为电子受体反硝化动力学的影响,本研究采用缺氧/厌氧UASB-SBR生化系统处理实际高氨氮垃圾渗滤液,在SBR系统实现稳短程生物脱氮(120d运行)的基础上,取SBR反应器内的污泥进行pH8.0条件下不同DO浓度梯度反硝化批次试验,从而确定DO对以NO2--N为电子受体的溶解氧抑制系数(K′O)的影响.试验结果表明,DO对反硝菌的NO2--N还原活性具有明显影响,与缺氧状态相比,DO为0.4和0.6mg·L-1时,其还原活性分别降低了49.0%和16.3%左右.DO与NO2--N还原速率两者呈指数负相关.DO对NO2--N为电子受体K′O具有显著影响,存在明显的分段现象,每一DO范围内,K′O恒定.